Repair vs Replace Driveway Cost in Melbourne (2026)
In Melbourne repairing or replacing a driveway turns on whether the base has failed, with reactive clay heaving and cracking a slab.
Repair or resurface
- Typical cost
- Crack sealing $15 to $30 per lineal metre. Concrete grinding to remove a trip lip $250 to $600. Asphalt pothole patching $150 to $400 each. Hot mix overlay $45 to $75 per m². Concrete resurfacing overlay $55 to $95 per m². Paver relay $50 to $90 per m².
- Expected remaining life
- Crack sealing buys 3 to 7 years. An asphalt overlay buys 8 to 15 years on a sound base. A concrete overlay buys 8 to 12. All of them are capped by the base beneath.
- Disruption and downtime
- Crack sealing and patching is a few hours with the driveway usable the next day. An overlay is one to two days plus 24 to 72 hours before vehicles.
- Ongoing cost
- Asphalt benefits from resealing every 5 to 8 years at roughly $8 to $15 per m². Concrete benefits from resealing every 3 to 5 years at $10 to $20 per m².
- Warranty
- Typically 12 months on patching, and 2 to 5 years on a professionally applied overlay from an established contractor.
- When it is false economy
- Overlaying a driveway that is stepping, rocking or ponding. The new surface will crack along exactly the same lines within one or two wet seasons because nothing beneath it changed.
Full replacement
- Typical cost
- Plain concrete $110 to $160 per m² including excavation and disposal. Exposed aggregate $140 to $220 per m². Asphalt $85 to $135 per m². Pavers $130 to $250 per m². Add $1,000 to $3,500 for a new crossover, drainage or retaining.
- Expected remaining life
- Concrete 30 to 50 years. Asphalt 15 to 25 with resealing. Pavers 25 to 40 with occasional relevelling. All assume a properly compacted base.
- Disruption and downtime
- Three to seven days including demolition, base preparation, pouring and curing. Vehicles stay off concrete for at least seven days and heavy vehicles for 28.
- Ongoing cost
- Concrete needs sealing every 3 to 5 years to resist oil staining. Asphalt needs resealing every 5 to 8. Pavers need occasional joint sand top up and weed control.
- Warranty
- Structural work above state thresholds carries statutory building warranty, commonly six years. Reputable concreters typically warrant workmanship for 5 to 10 years excluding normal shrinkage cracking at control joints.
- When it is false economy
- Ripping out a fifteen year old concrete driveway because of hairline shrinkage cracks at the control joints, which are exactly what those joints are for.
What a repair vs replace driveway costs in Melbourne
Deciding to repair or replace a driveway in Melbourne turns on whether the fault is in the surface or the base below, since patching, crack-filling or resurfacing a driveway with a sound base is far cheaper than a full replacement, but once the base has failed and the driveway is cracked through and subsiding, it must be dug out and re-laid. A surface crack or worn finish is a repair, while a sunken or heaved slab is a replacement, so the state of the base leads the decision.
Melbourne's reactive clay is the main driver, because the clay swells and shrinks sharply between the wet winter and the dry summer, which heaves and cracks a driveway slab laid on an inadequate base, so a cracked clay-affected driveway often needs replacing with a properly prepared and reinforced base. The cold, damp winter also lets water into a surface crack, which worsens it over time. A Victorian or Edwardian period home may have an old crossover worth upgrading. A shared driveway is a common-property matter, and a crossover on the council nature strip needs an approved contractor. Resurfacing or patching is paving and concreting work by a driveway contractor or concreter rather than a licensed building trade in Victoria.
Repairing or replacing a driveway is paving and concreting work by a driveway contractor or concreter rather than a licensed building trade, so no building licence applies, though a crossover on the council nature strip needs a council-approved contractor and a retaining element needs a licensed builder, in Victoria under the Victorian Building Authority for any building side. For a Melbourne home, the clearest way to decide repair against replace is by whether the base has failed, with reactive clay the thing that heaves and cracks a slab.
Compare against the national picture: Repair vs Replace Driveway Cost in Australia →
Repair vs Replace Driveway Cost in other cities
Frequently asked questions
How do I decide repair or replace for a driveway in Melbourne?
By whether the fault is in the surface or the base, so patching or resurfacing a sound base is cheap, but a cracked-through, subsiding slab must be dug out and re-laid in Melbourne.
Does reactive clay crack a driveway in Melbourne?
Yes. The reactive clay swells and shrinks sharply between wet winter and dry summer, which heaves and cracks a slab on an inadequate base, so a clay-affected Melbourne driveway often needs replacing with a prepared base.
Does the winter worsen driveway cracks in Melbourne?
Yes. The cold, damp winter lets water into a surface crack, which worsens it over time, so a crack is best sealed early on a Melbourne driveway.
Do I need a licence to redo a driveway in Melbourne?
No. It is paving and concreting work by a driveway contractor or concreter, not a licensed building trade, though a crossover needs a council-approved contractor, in Victoria under the Victorian Building Authority for any building side.